Results 1 to 4 of 4

Thread: New type of sponge can soak up and release spilled oil hundreds of times

  1. #1
    Administrator Aragorn's Avatar
    Join Date
    17th March 2015
    Location
    Middle-Earth
    Posts
    20,241
    Thanks
    88,440
    Thanked 80,969 Times in 20,255 Posts

    Thumbs Up New type of sponge can soak up and release spilled oil hundreds of times



    Source: New Scientist


    A new material can absorb up to 90 times its own weight in spilled oil and then be squeezed out like a sponge and reused, raising hopes for easier clean-up of oil spill sites.

    This contrasts with most commercial products for soaking up oil, called “sorbents”. These are generally only good for a single use, acting like a paper towel used to mop up a kitchen mess and then tossed away. The discarded sorbents and oil are then normally incinerated.

    But what if the oil could be recovered and the sorbent reused? The new material, created by Seth Darling and his colleagues at Argonne National Laboratory in Illinois, seems to allow for both of these processes, cutting waste.

    The oil sponge consists of a simple foam made of polyurethane or polyimide plastics and coated with “oil-loving” silane molecules with a sweet spot for capturing oil. Too little chemical attraction would render the sponge useless as an absorber, whereas too much would mean the oil could not be released.

    In laboratory tests, the researchers found that when engineered with just the right amount of silane, their foam could repeatedly soak up and release oil with no significant changes in capacity.

    But to determine whether this material could help sort out a big spill in marine waters, they needed to perform a special large-scale test.


    Recreating a spill

    To do this, the team made an array of square pads of the sponge material measuring around 6 square metres. “We made a lot of the foam, and then these pieces of foam were placed inside mesh bags – basically laundry bags, with sewn channels to house the foam,” Darling says.

    The researchers suspended their sponge-filled bags from a bridge over a large pool specially designed for practising emergency responses to oil spills.

    They then dragged the sponges behind a pipe spewing crude oil to test the material’s capability to remove oil from the water. They next sent the sponges through a wringer to remove the oil and then repeated the process, carrying out many tests over multiple days.

    This so-far unpublished test was conducted in early December at the National Oil Spill Response Research & Renewable Energy Test Facility in Leonardo, New Jersey.




    “Our treated foams did way better than either the untreated foam that we brought or the commercial sorbent,” says Darling.

    The team does not yet know, however, whether this material can perform well under the high pressures of the deep sea.

    Even so, this material could be used for spills near shores, where clean-up is particularly difficult. “I see it as a major advance in cleaning small spills and spills close to coastlines where dispersants cannot be used easily,” says Vijay John at Tulane University in New Orleans, Louisiana.

    “In an ideal world, you would have warehoused collections of this foam sitting near wherever there are offshore operations… or where there’s a lot of shipping traffic, or right on rigs… ready to go when the spill happens,” says Darling.

    The next challenge for the team is to optimise the process for scale-up.


    Journal reference: Journal of Materials Chemistry A, DOI: 10.1039/C6TA09014A


    Source: New Scientist
    = DEATH BEFORE DISHONOR =

  2. The Following 7 Users Say Thank You to Aragorn For This Useful Post:

    Dreamtimer (7th March 2017), Elen (7th March 2017), Greenbarry (8th March 2017), JRS (7th March 2017), modwiz (7th March 2017), pointessa (8th March 2017), yobear (7th March 2017)

  3. #2
    Retired Member Norway
    Join Date
    2nd July 2015
    Location
    Scotland
    Posts
    5,065
    Thanks
    73,935
    Thanked 23,318 Times in 5,067 Posts
    Plain and simple....GOOD NEWS!

  4. The Following 4 Users Say Thank You to Elen For This Useful Post:

    Aragorn (7th March 2017), Dreamtimer (7th March 2017), modwiz (7th March 2017), pointessa (8th March 2017)

  5. #3
    Retired Member
    Join Date
    22nd September 2013
    Posts
    1,141
    Thanks
    15,854
    Thanked 7,406 Times in 1,137 Posts
    Wonder if the oil can be recycled too? Win/Win totally !!

  6. The Following 6 Users Say Thank You to sandy For This Useful Post:

    Aragorn (8th March 2017), Dreamtimer (8th March 2017), Elen (9th March 2017), Greenbarry (8th March 2017), modwiz (8th March 2017), pointessa (8th March 2017)

  7. #4
    Administrator Aragorn's Avatar
    Join Date
    17th March 2015
    Location
    Middle-Earth
    Posts
    20,241
    Thanks
    88,440
    Thanked 80,969 Times in 20,255 Posts
    Quote Originally posted by sandy View Post
    Wonder if the oil can be recycled too? Win/Win totally !!
    Yes, it can be, according to the article. They can squeeze out the sponge and recuperate the oil.
    = DEATH BEFORE DISHONOR =

  8. The Following 3 Users Say Thank You to Aragorn For This Useful Post:

    Dreamtimer (8th March 2017), Elen (9th March 2017), sandy (9th March 2017)

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •